Finding a dry of tools to use, he walked over to the open space that had been left behind, ready to assemble the band saw.

If you want this band saw to be able to use normally, you can't just assemble the band saw and the sports car and put them together to use it normally, this thing has very strict requirements both in manufacturing and in the assembly process.

If it is placed in the outside world, Xu Yi wants to install a band saw, and he must not hesitate to find some professionals to help him solve this problem. After all, whether it is laying the foundation or installing, adjusting and straightening the band saw, it is all technical work that requires high precision and requires a lot of professional knowledge. Learning this knowledge alone for the installation of such a band saw must be a bit more than worth the loss.

But now he is going to put this thing in the space, and all the problems have to be solved by himself, so even if this thing is not cost-effective, he can only do it alone.

In order to install the band saw well, Xu Yi has racked his brains in the past two days, even when he comes to take the car, he is often not idle, either to determine the plan or to check the information, and finally come up with a relatively reliable method. Although this method is more cumbersome and the installation process can be a bit problematic, it can always represent some hope.

The first thing to do, of course, is to lay a foundation for this sawing machine, Xu Yi took a ruler and carefully measured the length and width of several sections of the track, calculated what he needed to make zuò, and took a few bamboo poles plus tape measures and ropes and walked to the edge of the clearing. Holding a bamboo pole and inserting it into the ground at a selected position, Xu Yi then measured it with a tape measure, and then circled the work area with a rope tied to the bamboo pole.

Then, Xu Yi carried a shovel along the piece of land that was raised. Dig up. The ground is soft. Plus Xu Yi's strength is also big enough. In just over ten hours, Xu Yi dug a square pit on the ground with a side length of 13 meters and a depth of almost one and a half meters.

Whether it's inside the space or outside, if you use cement and stone, it's not a building ready to build, and a half-meter-deep foundation like this is enough.

Xu Yi considered that there were no stones and cement in his space, so he would rather work harder to make the foundation more solid. Although the workload will definitely be larger, it will be able to ensure that you can assemble the band saw smoothly on the maximum length. It will not be affected by the foundation.

In addition, Xu Yi also thought that since the band saws were ready to be installed here, he was also going to put the rest of the machines on this place, and there were also many machines in those machines that also needed a solid foundation, so he was not doing useless work.

Stepping on a ladder to climb up from the pit, Xu Yi took out the manual of the tamping machine, and familiarized himself with the operation of the tamping machine, so he took the tamping machine to the bottom of the pit, turned on the power and got busy.

In the roar, the ground where the tamping machine passed all sank downward, and Xu Yi carefully did not fall into any corner. After the entire bottom of the pit is rammed, the motor is changed from horizontal to vertical and starts to work again.

Although according to the construction standard, it only needs to be done three times. However, Xu Yi looked at this machine, the efficiency was quite high, and the effect was very good, so he simply tamped the bottom of the pit three horizontally and three vertically. Originally, Xu Yi wanted to simply come twice more, but he also found that in fact, by the fourth time, the effect was no longer obvious, and by the sixth time, there was almost no effect at all.

Xu Yi went up to the outside of the pit, shoveled the surrounding soil and filled it into the pit, and piled up about 20 centimeters at the bottom of the pit, and then got busy again.

After he tamped the newly filled soil, Xu Yi suddenly found a problem, the four walls on the side of the pit were only about one meter high!

Xu Yi thought of what he had discovered when he was doing it before, so he simply stopped the tamping machine, directly moved everything out of the pit, and stood on the edge of the pit to observe carefully.

Although the speed was not very fast, he also noticed that the ground in the pit was slowly rising and the top was getting smoother and smoother.

It took more than an hour for the pit to disappear completely, and the whole ground looked unusually flat, and even a faint blue glow could be seen from the reflected light curtain on the ground, as if it was calendered with cement.

Xu Yi walked to it and found that he couldn't step on any traces at all, even if he tried to scrape the ground with his fingernails, only a shallow mark was left, and it was obvious that the hardness of the ground now was definitely very different from the softness of stepping on a footprint before.

Xu Yi took a shovel and dug on the side, feeling like digging the kind of ruts that have been run over by vehicles all year round, which is extremely hard. Even he exerted too much force, and he could hear the clattering sound of the shovel under his feet under his feet.

With a lot of effort, Xu Yi only dug down a fist-sized clod of soil on the ground.

Then he added some crumble of earth to the excavated pit, and the previous scene reappeared, and in a short time, the pit was completely restored.

However, even though the ground looked very flat, Xu Yi was still ready to test the ground again.

Xu Yi didn't have a ruler or feeler gauge specifically to check the flatness of the floor and wall, so he was going to make a simple zuò.

Cutting off a strip of about five centimeters wide from a board, Xu Yi directly took a long planer and carefully planed its two long sides, and after checking that it was completely straight, he directly took it to the ground, and then gently leaned the flat side against the ground, and then took a piece of shavings of varying thickness and stuffed it into the middle of the ruler and the ground. To Xu Yi's great satisfaction, even the thinnest shavings could not fit into this gap at all, and then he picked up the ruler and rotated it 90 degrees before repeating the previous process.

After repeating this, Xu Yi spent a long time inspecting the entire ground.

The result made him unexpectedly satisfied, the ground that grew by himself was completely level, at least if he checked it in this way, there were no uneven places at all!

Although Xu Yi couldn't explain this phenomenon, it was obvious that this result was completely beneficial to his plan, so he didn't think much about it and directly recognized such a result.

Of course, even if it is so hard, such a ground still cannot fully meet the conditions for Xu Yi to install a band saw, and if you want to assemble this band saw, you have to have more preparations.

After all, the ground is made of dirt anyway, and the hardness is quite limited. If you put the band saw and the rail on the ground directly, I am afraid that the ground will be pressed down soon. Especially when the band saw is running at high speed, it is bound to produce a certain amount of vibration.

When he first got it into the space, Xu Yi estimated the weight of the band saw, and felt that the goods were almost 1,800 catties connected to the box outside, and the impact effect on the ground of such a heavy machine was definitely far greater than that of the tamping machine.

For this problem, Xu Yi has already thought of preventive measures.

His plan was very simple: after the ground was tamped, a layer of wooden planks was laid on top of it, and then a layer of sleepers was laid on the ground on top of these planks like a railroad, and then the machine qì and the ground rails were fixed on the sleepers.

In this way, the action of the guò sleepers and planks perfectly distributes the vibrations and pressures of the band saw and the sports car to the entire ground.

But there is no doubt that if you want to install a band saw to do this, you need to have some wood, unless you buy wood, or you have to find a way to process it. But the band saw is not in place, and the wood cannot be processed...... It's an endless loop!

However, Xu Yi had already considered this problem, and he didn't plan to spend any more money to buy wood, but he also had a perfect solution to this problem.

Although most of the laminated materials that Xu Yi bought before and after were used by him, there were still some boards on the ground in the tent that could be removed, and in addition to these, he also left a few boards specially for drying things that could also be used.

After all, as long as he waits until he has installed the band saw, he can have as many boards as he wants in the future, and there is no shortage of the little thing he uses now!

Of course, these boards don't solve all the problems, and more materials have to rely on those logs.

Xu Yi checked the newly cut logs yesterday, and they were all wet to the touch, and they definitely couldn't be used. Xu Yi actually paid attention to the dozens of logs that he had cut down before and built the shelves.

Xu Yi took a ruler to the wooden stack and measured it, then took a pen and paper and calculated it, and finally came to the conclusion that if these woods were carefully used, there would be absolutely no problem with assembling the band saw.

All that's left is to verify that the wood is really dry, at least if not completely, then at least to make sure that it is not absorbed by the ground.

Xu Yi is really not worried about the deformation due to force and other reasons, after all, the homogeneity of the materials in these woods is very good, and there are no growth rings, so there is no need to worry about deformation due to drying. Not to mention the outside world, you have to consider the problem of wood preservation.

However, out of prudence, Xu Yi is ready to make a little more real before processing. If it really doesn't dry out and may be absorbed by the ground, then I'd rather wait for another day and a half, presumably the wood can be completely dried, and it's not too late to install it at that time.

Xu Yi directly carried a red pine log and walked towards the workbench, and felt that the wood felt much lighter than yesterday, and he felt a lot more grasped in his heart.

After all, another day has passed in the outside world, and almost a month has passed in the space, and this log has obviously dried out a lot. (To be continued......)