Chapter 513 - Shoe Glue Problem Discovered (Page 1/1)

The production of products also needs to be inspected before delivery, which belongs to the category of quality management, Li Huan is most concerned about this, quality is related to brand reputation.

When he came to the quality inspection center, Li Huan saw that the inspectors were doing various spot checks and functional tests.

According to the different inspections, it is divided into incoming experience, semi-finished product inspection and finished product factory inspection.

Among them, the experience of incoming materials is the first level, and the factory inspection is the last level, which is very important.

Incoming inspection can prevent unqualified raw materials from entering the production process and effectively reduce the rate of defective products.

The factory inspection of finished products can prevent unqualified products from entering the market and increase customer satisfaction.

Inspection and testing are not like assembly lines, many of them can be paused.

Every time Li Huan came to an inspection room, he would be warmly welcomed by the inspectors.

With a sunny and friendly smile, Li Huan chatted with the inspectors about the topic of product inspection and asked them about the quality problems they encountered during the inspection.

Because the manager of the quality control department and the vice president of production are accompanied, the inspectors will of course pick up the good ones, even when it comes to quality problems, they are all corrected or insignificant problems.

Li Huan didn't think that a random inspection could find any big problems, he just came to take a look, after all, as one of the bosses and a brand spokesperson, he must be responsible for the brand he endorses.

However, when Li Huan came to the incoming inspection area, Liao Yong, the incoming inspector here, reported to him the quality of the incoming materials.

According to Liao Yong's introduction, the special shoe glue sent yesterday had unqualified heat resistance, and the inspection report he gave was that the product was unqualified and recommended to be returned.

However, Jia Feiyu, the supervisor of incoming inspection, said that the heat resistance performance is only a little bit away from qualifying, and the problem is not big, and it is winter again, and the temperature is low, which is no problem at all, so Liao Yong modified the inspection data to be qualified.

Liao Yong graduated this year and is now an intern, and he can't figure out this kind of changing unqualified materials to qualified, and he has been struggling whether to report directly to the general manager, because Zhang Na went to the school to recruit for an internship here, and they all have Zhang Na's contact information.

Now seeing that Li Huan, a star player and one of the bosses of the company, came to inspect the work, he told the situation in a horizontal way, which made the director of the quality control department and the incoming inspection supervisor on the side break out in a cold sweat.

Li Huan was also surprised when he heard it, the raw materials that were obviously inspected as unqualified were changed to qualified acceptance, if there was no bit of catticity in it, he would not believe it.

Li Huan was not in a hurry, and said with a smile: "Your name is Liao Yong, I am a basketball player, and I don't understand the quality, you slowly tell me what is the impact of the heat resistance of this special shoe glue on the quality of shoes." ”

Liao Yong is actually hanging in his heart, he is interning here, and he has to take the comments of the supervisor here, if he offends people Li Huan and doesn't ask, then he is not a person inside and out.

Fortunately, Li Huan seems to be very interested in this now, so he doesn't care about the directors and ministers on the side, and immediately tells the truth.

After hearing this, Li Huan learned that this special shoe glue is specially used to process youth trapeze sneakers.

The genuine qualified special shoe glue is of good quality and high price, and the viscose of the sneakers produced with it is firm, it is not easy to open the glue, and it can withstand higher temperature and stronger impact.

The height and weight of basketball players are not comparable to ordinary people, so the requirements for shoe glue are higher.

Shoe glue needs to be stored in an environment below 30 °C, and when it is higher than 30 °C, the moisture in the shoe glue will evaporate, resulting in the condensation of the surface of the shoe glue, or the cracking effect will destroy the physical properties of the shoe glue itself, resulting in the phenomenon of opening the glue in the process of using shoe glue.

Yesterday, when the special shoe glue was sent, Liao Yong found that the surface of a bucket of shoe glue was condensed, like this kind of winter weather, the highest temperature is only about ten degrees, and the conjunctiva indicates that the nature of shoe glue has changed.

Sure enough, after doing the heat resistance test, the shoe glue this time was unqualified.

Although Li Huan doesn't understand shoe glue, he knows how big the problem of shoe glue is, and the quality of shoe glue can't be sloppy at all, especially the Youth Flyer-LH is named after him, and there can be no obvious quality problems.

Li Huan immediately asked Han Liwei in a piece: "Mr. Han, how is the production of Youth Flyer-LH, and has this batch of special shoe glue begun to be used in production?" ”

Han Liwei actually wanted to scold the quality minister and the incoming inspection supervisor, even the special shoe glue of the youth trapeze sneakers dared to be sloppy, if there was really a problem, then it would be repaid, so he hurriedly said: "Li Dong, this batch of special shoe glue has not been used yet, I will immediately notify the manufacturer to return it." ”

Hearing that it hasn't been used yet, Li Huan also breathed a sigh of relief and said: "It's good that it's not used, the quality control department will immediately issue a non-qualified inspection report and let the manufacturer ship it back." By the way, was it also the special shoe glue of this factory before? ”

Han Liwei shook his head and said: "No, this one is a new supplier, the samples we were given before are still very good, Xiao Liao has also done experiments, I also read the inspection report at the time, it is not worse than the original supplier, but the price is one-third lower." ”

Li Huan looked at Liao Yong, and Liao Yong immediately replied: "What Mr. Han said is right, I also did the inspection at that time, and the samples of this new supplier were brought over and the inspection results were good, so I issued a qualified report." ”

Li Huan nodded in approval, and then asked, "Mr. Han, since the original supplier is fine, why don't you continue to use the original supplier and change the supplier?" ”

Han Liwei was very patient, explaining: "In order to prevent suppliers from running out of stock, enterprises generally choose multiple suppliers, one can shop around, and the other is also the need for reasonable price control." ”

Li Huan is right to think about it, since it is a business, then profits need to be considered, and the benefits of choosing multiple suppliers are also obvious, they will have healthy competition, and it is not easy to ask for prices and raise prices.

So Li Huan nodded and asked, "Mr. Han, how much inventory of the original special shoe glue is there in the warehouse?" ”

Han Liwei immediately replied: "It's probably enough for three days." ”

Judging from Han Liwei's calm answer, Li Huan felt that Han Liwei was responsible, and said: "Now immediately order from the original supplier, at this juncture of the year, ensuring production and quality is the most critical, and then study the problem of new suppliers later." ”

Han Liwei hurriedly replied, "Okay, Li Dong." ”

Li Huan patted Liao Yong on the shoulder and said: "Liao Yong, this time you as an inspector blocked the substandard products from entering the production process, you should remember a great achievement, I will tell Mr. Zhang directly about this matter, and I will make a commendation at the year-end commendation meeting, I hope you will continue to adhere to the principle of quality first, and strive to control the incoming materials, thank you." ”

Book Keju Reading Website: